Utilization of Biogas Liquid Waste For Starter In The Fermentation of Rice Husk As A Potential Feed For Poultry

  • Osfar Sjofjan Animal Science Faculty, University of Brawijaya, Malang, Indonesia.
  • Danung Nur Adli Animal Science Faculty, University of Brawijaya, Malang, Indonesia.
  • Irfan Djunaidi Animal Science Faculty, University of Brawijaya, Malang, Indonesia.
  • Kuncoro Animal Science Faculty, University of Brawijaya, Malang, Indonesia.
Keywords: rice husk, biogas liquid waste, fermentation, alternative feed

Abstract

The research was aimed to evaluate the effect of biogas liquid waste as a fermentation  starter of  rice husk to the nutrient content, gross energy and bulk density. The method  used laboratory experiment using a completely randomized design (CRD) on factorial  pattern (6 x 5) with the level of biogas waste liquid : P0-treatment (0% negative control), P0+ (Cellulomonas sp as positive control), P1 (5%), P2 (10%), P3 (15%), P4 (20%) ml/g, and the incubation time :  T0 (0 day control ), T1(7 days), T2 (14 days), T3 (21 days)  and  T4 (28 days). The variables  measured was the content of ash, crude protein, crude fiber, crude fat, gross energy and bulk density.  Data were analyzed by  analysis of variance  (anova)  CRD  Factorial  pattern and if there is a significant  difference  was followed  by  Duncan's  Multiple  Range  Test. The results of research  was  the  level of biogas  liquid waste and the  incubation  time  provides a significant  influence (P<0.01) on the nutrient content, gross energy and bulk density of rice husk. The  interaction  level  liquid waste  provision  of  biogas  and incubation time was highly significant  (P<0.01) on  the nutrient content, gross energy and bulk density. It can be concluded that the  addition of biogas liquid waste 15% (ml/g) with a time of incubation  for 21 days have best rice husk quality content based on improvement of crude protein, crude fat, and gross energy with lowest crude fiber.

References

Aderolu, AZ, EA Ayiyi, and AA Onilude. 2007. Changes in Nutritional Value of Rice Husk during Trichoderma viride Degradation. Bulgarian Journal of Agricultural Science. 13 (7): 583-589.

Adli, DN, O Sjofjan, and Mashudi. 2017. Dried of Poultry Waste Urea-Molasses Block (dpw-umb) as Potential for Feed Supplementation. Jurnal Agripet. 17(2): 144-149.

Adli, DN, O Sjofjan. 2018. Nutrient content evaluation of dried poultry waste urea molasses block (DPW-UMB) on In-vitro analysis. Sains Peternakan. 16(2): 50-53.

Adli, DN, O Sjofjan, and Mashudi. 2018. Nutrient content evaluation of dried poultry waste urea-molasses block (dpw-umb) on proximate analysis. Jurnal Ilmu-Ilmu Peternakan. 28(1): 84-89.

Adli, DN, Y Chi, JW Lee, and O Sjofjan. 2019. Supplementation Mannan-Rich Fraction (MRF) and/or Combination with Probiotic-Enhanced Water Acidifier on Dietary Female Broiler at 28 days as Natural Growth Promoters (NGPs). Research Journal of Advanced Engineering and Science. 4(3): 427-429.

Adli, DN, O Sjofjan, and Mashudi. 2019. Nutrient content evaluation of dried of poultry waste urea-molasses block (dpw-umb) on proximate analysis. Jurnal Ilmu dan Teknologi Peternakan. 6(2): 72-76.

Adli, DN, and Sjofjan, O. 2020. Growth performance, serum blood biochemistry, and intestinal properties of Arbor Acres Broiler fed diets containing mannan-riched fraction (MRF) and probiotic-enhanced liquid acidifier. Buletin Peternakan. 44(2).

Badan Pusat Statistik. 2014. Berita Resmi Statistik. Produksi Padi, Jagung, dan Kedelai: Angka Ramalan 1 Tahun 2014 : 1-10.

Bata, M. 2008. Pengaruh Molases pada Amoniasi Jerami Padi Menggunakan Urea terhadap Kecernaan Bahan Kering dan Bahan Organik In-Vitro. Jurnal Agripet, 1(3) : 15-20.

Daniel, O Sjofjan, dan IH Djunaidi. 2014. Kajian Kandungan Zat Makanan dan Pigmen Antosianin Tiga Jenis Kulit Buah Naga (Hylocereus sp) sebagai Bahan Pakan Ternak. Jurnal Ilmu-ilmu Peternakan, 12(5): 1-9.

Fang, HHP, C Li, and T. Zhang. 2006. Acidophilic Biohydrogen Production from Rice Slurry. International Journal of Hydrogen Energy. 11(3) : 683-692.

Gamayanti, KN, A Pertiwiningrum, dan LM Yusiati. 2012. Pengaruh Penggunaan Limbah Cairan Rumen dan Lumpur Gambut sebagai Starter dalam Proses Fermentasi Metanogenik. Buletin Peternakan. 3(4) : 32-39.

Hidayat, IR, Kusrahayu, dan S Mulyani. 2013. Total Bakteri Asam Laktat, Nilai ph dan Sifat Organoleptik Drink Yoghurt dari Susu Sapi yang diperkaya dengan Ekstrat Buah Mangga. Animal Agriculture Journal.17(6) : 162-163.

Joseph, I, RP Raj, , and D Bhatnagar. 2008. Effect of solid state fermentation on nutrient composition of selected ingredients. Indian Journal of Fish.12(1) : 327-332.

Lashkari, S, A Taghizadeh, J Selfidayati, and AZM Salem. 2014. Qualitative Characteristics, Microbial Populations and Nutritive values of Orange Pulp Ensiled with Nitrogen Supplementation. Slovakian Journal Animal Science. 8(9) : 90-99.

Ligyarohman, F, MH Natsir,, dan IH Djunaidi. 2014. Pengaruh Pemberian Level Dedak yang berbeda dengan Penambahan Xilanase dalam pakan terhadap Berat Organ Dalam dan Kualitas Karkas Ayam Pedaging. Jurnal Ilmu-ilmu peternakan. 5(6) : 1-6.

Lunar, A.M, Supratman, H., dan Abun. 2012. Pengaruh Dosis Inokulum dan Lama Fermentasi Buah Ketapang (Ficus lyrata) oleh Aspergilus niger terhadap Bahan Kering, Serat Kasar, dan Energy Bruto. Jurnal nutrisi ternak dan pakan tropis, 2(3) : 1-6.

Mangunwidjaja, D., Sukmaratri, T.E., dan Setiyarto, C. 2015. Peningkatan Kadar Protein Kasar Ampas Kulit Nanas melalui Fermentasi Media Padat. Buletin Peternakan, 3(4): 12-16.

Nasution, DY. 2006. Pengaruh Ukuran Partikel dan Berat Abu Sekam Padi sebagai Pengisi terhadap Sifat Kuat Sobek, Kekerasan, dan Ketahanan Abrasi Kompon. Jurnal Sains Kimia. 10 (2): 86-91.

Prabhu, AA, CM Mrudula, and J Rajesh. 2014. Effect of Yeast Fermentation on Nutraceutical and Antioxidant Properties of Rice Bran. International Journal of Agricultural and Food Science. 2(3) : 59-65.

Safitri R. 2014. The Influence of Fermentation by Bacillus circulans, Micrococcus sp., and B. coagulans Towards Fat, Crude Fiber and Protein Content of Palm Oil Empty Fruit Bunches Waste (Elaeis guineensis Jacq.). University of Agricultural Sciences and Veterinary Medicine, Surabaya.

Safitri, R, and Wahyudi, R.R. 2011. Effect of Consortium Trichoderma viride, Trichoderma reesei, Aspergillus oryzae and Rhizopus oligosporus, and Dose on Inoculant Viability, Reducing Sugar and Nutritional Value of Corn Cobs. International Seminar Biotechnology : Agustus 2011. Pp:33-46.

Sjofjan, O, DN Adli, PK Hanani, and D Sulistiyaningrum. 2019.The utilization of bay leaf (SyzygiumpolyanthumWalp) Flour in feed on carcass quality, microflora instestine of broiler. International Journal of Engineering Technologies and Management Research. 6(11):1-9.

Sjofjan, O, DN Adli, MH Natsir, dan A Kusumaningtyaswati. 2020. Pengaruh kombinasi tepung kunyit (curcuma domestica val.) dan probiotik terhadap penampilan usus ayam pedaging. Jurnal Nutrisi Ternak Tropis dan Ilmu Pakan. 2 (1):19-24.

Sjofjan, O, and Adli, DN. 2020. Effect of Dietary of Supplementation Mannan-Riched Fraction (MRF) and Probiotic-Enhanced Liquid Acidifier on the Growth Performance, Serum Blood Biochemistry, and Intestinal Properties of Broilers. In IOP Conference Series: Earth and Environmental Science. 478(1): 012066. IOP Publishing.

Sjofjan, O, Natsir, MH, Adli, DN, Adelina, DD, and Triana, LM. 2020. Effect Of Symbiotic Flour (Lactobacillus Sp. And FOS) To The Egg Quality And Performance Of Laying Hens. In IOP Conference Series: Earth and Environmental Science. 465(1): 012033. IOP Publishing.

Suparjo dan Nelson. 2011. Penentuan Lama Fermentasi Kulit Buah Kakao dengan Phanerochaete chrysosporium : Evaluasi Kualitas Nutrisi secara Kimiawi. Agrinak. 1(2) : 1-10.

Suryanata, IK, IH Djunaidi, dan MH Natsir. 2013. Pengaruh Penambahan Xylanase dalam pakan dengan Level Dedak yang Berbeda terhadap Kualitas Fisik Daging Ayam Pedaging. Jurnal Ilmu-Ilmu Peternakan. 1(3) : 1-8.

Telew, C, VG Kereh, IM Unt, dan BW Rembet, B.W. 2013. Pengayaan Nilai Nutritif Sekam Padi berbasis Bioteknologi "Effective Mikroorganisms" (EM4) sebagai Bahan Pakan Organik. Jurnal Zootek . 32 (5): 1-8.

Widiyawati, I, O Sjofjan, dan DN Adli. 2020. Peningkatan Kualitas dan Persentase Karkas Ayam Pedaging dengan Subtitusi Bungkil Kedelai Menggunakan Tepung Biji Asam (Tamarindus indica L) Fermentasi. Jurnal Nutrisi Ternak Tropis. 3(1): 35-40.

Yunilas. 2009. Bioteknologi Jerami Padi melalui Fermentasi sebagai Bahan Pakan Ternak Ruminansia, Medan.123 halaman

Published
2020-07-06
How to Cite
Sjofjan, O., Nur Adli, D., Djunaidi , I., & Kuncoro, K. (2020). Utilization of Biogas Liquid Waste For Starter In The Fermentation of Rice Husk As A Potential Feed For Poultry. ANIMAL PRODUCTION, 22(1), 24-30. https://doi.org/10.20884/1.jap.2020.22.1.38
Section
Articles